MUET logo

Sugarcane Bagasse Biochar as a Sustainable Adsorbent for Cadmium Removal from Wastewater

Authors

  • Maham Nawaz

    Department of Environmental Sciences, Faculty of Science, University of Gujrat, Gujrat, 50700, Pakistan
    Author

  • Kiran Hina

    epartment of Environmental Sciences, Faculty of Science, University of Gujrat, Gujrat, 50700, Pakistan
    Author

  • Qaiser Hussain

    Institute of Soil Science, Pir Mehr Ali Shah Arid Agriculture University, Rawalpindi, Pakistan
    Author

  • Yousuf Jamal

    Institute of Chemical Engineering and Technology, University of the Punjab, Lahore, 54590, Pakistan
    Author

  • Iram Gul

    Institute of Environmental Sciences and Engineering, National University of Sciences and Technology (NUST), Islamabad, 44000, Pakistan
    Author

  • Muhammad Arshad

    Institute of Environmental Sciences and Engineering, National University of Sciences and Technology (NUST), Islamabad, 44000, Pakistan
    Author

DOI:

https://doi.org/10.22581/0561

Keywords:

Fourier Transmission Infrared Spectroscopy (FTIR), Adsorption, Cadmium, Isotherms, Sugarcane Bagasse Biochar , Wastewater Treatment

Abstract

With rapid industrial expansion, effective wastewater treatment has become an urgent environmental priority. Industrial effluents contain diverse pollutants, including toxic heavy metals, organic and inorganic contaminants, and microplastics. Among these, cadmium (Cd) is a persistent, non-biodegradable heavy metal released through electroplating, mining, and agricultural activities, posing severe ecological and human health risks. This study evaluates the efficacy of chemically unmodified sugarcane bagasse biochar as a sustainable adsorbent for removing Cd from aqueous solutions. Sugarcane bagasse biochar was prepared via slow pyrolysis in a muffle furnace at 550 °C at Pir Mehr Ali Shah Arid Agriculture University, Rawalpindi, and surface functional groups were characterized before and after adsorption using Fourier Transform Infrared Spectroscopy (FTIR). Batch adsorption experiments evaluated the effects of solution pH (2–12), initial Cd concentration (5–100 mg/L), adsorbent dosage (0.5–3.0 g/L), and contact time (10–180 min) on Cd removal efficiency and adsorption capacity. Optimal removal was achieved at pH 10, an initial Cd concentration of 25 mg/L, an adsorbent dose of 3.0 g, and a contact time of 90 min, yielding removal efficiencies of 98.6% (at pH 10) and up to 99.8% (at a 3.0 g dose). Equilibrium data were modeled using the Langmuir and Freundlich isotherms; the Langmuir isotherm provided the best fit (R² = 0.999), confirming monolayer chemisorption on a homogeneous surface with a maximum adsorption capacity (qmax) of 24.45 mg/g. Desorption experiments using 0.1 M CaCl2 and 0.1 M HCl demonstrated that CaCl2 achieved higher desorption efficiency (67.98% vs. 60.46% at 100 mg/L) due to the stronger competitive displacement of divalent Ca2+ ions compared with monovalent H+ ions. These findings demonstrate that unmodified sugarcane bagasse biochar is a low-cost, chemical-free, and sustainable adsorbent for cadmium remediation.

Downloads

Author Biographies

  • Kiran Hina, epartment of Environmental Sciences, Faculty of Science, University of Gujrat, Gujrat, 50700, Pakistan

    Dr Kiran Hina is working as an associate professor in department of environmental sciences in university of gujrat

  • Qaiser Hussain, Institute of Soil Science, Pir Mehr Ali Shah Arid Agriculture University, Rawalpindi, Pakistan

    He is serving as an associate professor in Arid Agriculture university in Rawalpindi.

  • Yousuf Jamal, Institute of Chemical Engineering and Technology, University of the Punjab, Lahore, 54590, Pakistan

    he is serving as an Associate Professor in University of punjab, Chemical Engineering

  • Iram Gul, Institute of Environmental Sciences and Engineering, National University of Sciences and Technology (NUST), Islamabad, 44000, Pakistan

    she is serving as an associate professor in Nust university.

  • Muhammad Arshad, Institute of Environmental Sciences and Engineering, National University of Sciences and Technology (NUST), Islamabad, 44000, Pakistan

    Prof. Dr. Muhammad Arshad is serving in the Institute of Environmental Sciences and Engineering (IESE) as Associate Dean within the School of Civil and Environmental Engineering (SCEE). 

References

[1] K. Rao, M. Mohapatra, S. Anand, and P. Venkateswarlu, “Review on cadmium removal from aqueous solutions,” International Journal of Engineering, Science and Technology, vol. 2, no. 7, pp. 81–103, 2011.

[2] S. Muhammad, M. T. Shah, and S. Khan, “Health risk assessment of heavy metals and their source apportionment in drinking water of Kohistan re- gion, northern Pakistan,” Microchemical Journal, vol. 98, no. 2, pp. 334–343, 2011.

[3] M. Momina, M. Shahadat, and S. Ismail, “Regen- eration performance of clay-based adsorbents for the removal of industrial dyes: A review,” RSC Advances, vol. 8, no. 43, pp. 24571–24587, 2018.

[4] M. J. McLaughlin, E. Smolders, F. J. Zhao, C. Grant, and D. Montalvo, “Managing cadmium in agricultural systems,” in Advances in Agronomy (D. L. Sparks, ed.), vol. 166, pp. 1–129, Academic Press, 2021.

[5] H. Ali and E. Khan, “Trophic transfer, bioaccu- mulation, and biomagnification of non-essential hazardous heavy metals and metalloids in food chains/webs—concepts and implications for wildlife and human health,” Human and Ecolog- ical Risk Assessment: An International Journal, vol. 25, no. 6, pp. 1353–1376, 2019.

[6] P. Verzelloni, T. Urbano, L. A. Wise, M. Vinceti, and T. Filippini, “Cadmium exposure and cardio- vascular disease risk: A systematic review and dose-response meta-analysis,” Environmental Pol- lution, vol. 345, p. 123462, 2024.

[7] S. Riaz, G. Murtaza, M. Saqib, and M. Hameed, “Synergistic contribution of sugarcane bagasse and derived biochar: Insights into cadmium stress toler- ance of maize (Zea mays l.) with physicochemical exploration,” Soil & Environment, vol. 43, no. 2, pp. 230–247, 2024.

[8] V. Singh, N. Singh, S. N. Rai, A. Kumar, A. K. Singh, M. P. Singh, A. Sahoo, S. Shekhar, E. Va- manu, and V. Mishra, “Heavy metal contamination in the aquatic ecosystem: Toxicity and its reme- diation using eco-friendly approaches,” Toxics, vol. 11, no. 2, p. 147, 2023.

[9] M. Bashir, S. Y. Mohammed, M. K. Atiku, A. U. Bello, and H. A. Yakasai, “Heavy metals content in laboratory wastewater: A case study of selected units of Bayero University, Kano, Nigeria,” Bayero Journal of Pure and Applied Sciences, vol. 14, no. 2, pp. 174–177, 2022.

[10] M. Azadian and H. G. Gilani, “Adsorption of Cu2+, Cd2+, and Zn2+ by engineered biochar: Prepara- tion, characterization, and adsorption properties,” Environmental Progress & Sustainable Energy, vol. 42, no. 4, p. e14088, 2023.

[11] D. Mohan, A. Sarswat, Y. S. Ok, and C. U. Pittman, “Organic and inorganic contaminant removal from water with biochar, a renewable, low-cost, and sustainable adsorbent—a critical review,” Biore- source Technology, vol. 160, pp. 191–202, 2014.

[12] P. Sun, C. Hui, R. A. Khan, J. Du, Q. Zhang, and Y. H. Zhao, “Efficient removal of crystal violet using Fe3O4-coated biochar: The role of the Fe3O4 nanoparticles and modeling study of their adsorp- tion behavior,” Scientific Reports, vol. 5, p. 12638, 2015.

[13] Priyanka, D. Vashisht, M. J. Taylor, and S. K. Mehta, “Evaluating the pre-treatment protocol required to produce an effective carbonized waste adsorbent for organic pollution control,” Frontiers in Environmental Science, vol. 11, p. 1224388, 2023.

[14] C. Zhao, B. Wang, B. K. G. Theng, P. Wu, F. Liu, S. Wang, X. Lee, M. Chen, L. Li, and X. Zhang, “Formation and mechanisms of nano-metal oxide- biochar composites for pollutant removal: A re- view,” Science of the Total Environment, vol. 767, p. 145305, 2021.

[15] P. Parmar, B. C. Meikap, and S. Mukherjee, “As- sessment of sugarcane bagasse through thermo- kinetic study as a sustainable energy resource,” Research Square, 2023. rs.3.rs-2991592/v1.

[16] A. Triyani, M. F. Fachrul, and A. Minarti, “Poten- tial utilization of sugarcane bagasse as raw material for bioethanol production,” IOP Conference Se- ries: Earth and Environmental Science, vol. 1203, no. 1, p. 012003, 2023.

[17] M. Inyang, B. Gao, W. Ding, P. Pullammanappallil, A. R. Zimmerman, and X. Cao, “Enhanced lead sorption by biochar derived from anaerobically digested sugarcane bagasse,” Separation Science and Technology, vol. 46, no. 12, pp. 1950–1956, 2011.

[18] M. M. A. Bakr, Y. Wang, P. Hao, M. M. A. Dawoud, L. Peng, and Y. Wang, “Biochar from Al(OH)3- activated sugarcane bagasse for efficient removal of cadmium: Optimization using the response surface method (RSM),” Biomass Conversion and Biorefinery, vol. 15, no. 12, pp. 19487–19504, 2025.

[19] M. E. Saleh, Y. A. El-Damarawy, F. F. Assad, A. A. Abdesalam, and R. A. Yousef, “Removal of copper metal ions by sugarcane bagasse and rice husk biochars from contaminated aqueous solutions,” Mediterranean Journal of Soil Science, vol. 1, no. 1, pp. 1–17, 2020.

[20] Y. Meng, “A sustainable approach to fabricating Ag nanoparticles/PVA hybrid nanofiber and its catalytic activity,” Nanomaterials, vol. 5, no. 2, pp. 1124–1135, 2015.

[21] R. K. Sharma, J. B. Wooten, V. L. Baliga, X. Lin, W. G. Chan, and M. R. Hajaligol, “Characterization of chars from pyrolysis of lignin,” Fuel, vol. 83, no. 11–12, pp. 1469–1482, 2004.

[22] D. Nagarajan and S. Venkatanarasimhan, “Cop- per(II) oxide nanoparticles coated cellulose sponge—an effective heterogeneous catalyst for the reduction of toxic organic dyes,” Environmen- tal Science and Pollution Research, vol. 26, no. 22, pp. 22958–22970, 2019.

[23] M. Fan, D. Dai, and B. Huang, “Fourier trans- form infrared spectroscopy for natural fibers,” in Fourier Transform—Materials Analysis, Inte- chOpen, 2012.

[24] C. Navas-Cárdenas, M. Caetano, D. Endara, R. Jiménez, A. B. Lozada, L. E. Manangón, A. Navarrete, C. Reinoso, A. E. Sommer-Márquez, and Y. Villasana, “The role of oxygenated func- tional groups on cadmium removal using pyrochar and hydrochar derived from Guadua angustifolia residues,” Water, vol. 15, no. 3, p. 525, 2023.

[25] B. H. Stuart, Infrared Spectroscopy: Fundamentals and Applications. Wiley, 2004.

[26] P. Gole, K. Raut, and B. Kandasubramanian, “Polymer-based biochar materials for environmen- tal remediation: A review,” Hybrid Advances, vol. 6, p. 100267, 2024.

[27] A. Tomczyk, Z. Sokołowska, and P. Boguta, “Biochar physicochemical properties: Pyrolysis temperature and feedstock kind effects,” Reviews in Environmental Science and Bio/Technology, vol. 19, no. 1, pp. 191–215, 2020.

[28] P. Kumar and P. Kumar, “Removal of cadmium (Cd-II) from aqueous solution using a gas industrybased adsorbent,” SN Applied Sciences, vol. 1, no. 4, p. 365, 2019.

[29] M. A. Naeem, M. Imran, M. Amjad, G. Abbas, M. Tahir, B. Murtaza, A. Zakir, M. Shahid, L. Bul- gariu, and I. Ahmad, “Batch and column scale removal of cadmium from water using raw and acid-activated wheat straw biochar,” Water, vol. 11, no. 7, p. 1438, 2019.

[30] X. Chen, G. Chen, L. Chen, Y. Chen, J. Lehmann, M. B. McBride, and A. G. Hay, “Adsorption of cop- per and zinc by biochars produced from pyrolysis of hardwood and corn straw in aqueous solution,” Bioresource Technology, vol. 102, no. 19, pp. 8877– 8884, 2011.

[31] B. S. L. Coleman, Z. M. Easton, and E. M. Bock, “Biochar fails to enhance nutrient removal in woodchip bioreactor columns following satu- ration,” Journal of Environmental Management, vol. 232, pp. 490–498, 2019.

[32] B. Chen, Z. Chen, and S. Lv, “A novel magnetic biochar efficiently sorbs organic pollutants and phosphate,” Bioresource Technology, vol. 102, no. 2, pp. 716–723, 2011.

[33] X. Xu, X. Cao, L. Zhao, H. Wang, H. Yu, and B. Gao, “Removal of Cu, Zn, and Cd from aqueous solutions by the dairy manure-derived biochar,” Environmental Science and Pollution Research, vol. 20, no. 1, pp. 358–368, 2013.

[34] X. Huang, X. Hou, F. Song, J. Zhao, and L. Zhang, “Facet-dependent Cr(VI) adsorption of hematite nanocrystals,” Environmental Science & Technol- ogy, vol. 50, no. 4, pp. 1964–1972, 2016.

[35] A. Gameel, I. M. Farid, H. Jahin, M. H. Abbas, and M. Bassouny, “Kinetics of cadmium removal from aqueous solutions by iron-enriched biochar,” Environment, Biodiversity and Soil Security, vol. 8, pp. 125–130, 2024.

Published

2026-10-01

Issue

Vol. 45 No. 4 (2026): October Issue

Section

Articles

License

Copyright (c) 2026 Mehran University Research Journal of Engineering and Technology

Creative Commons License

This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.

How to Cite

Sugarcane Bagasse Biochar as a Sustainable Adsorbent for Cadmium Removal from Wastewater. (2026). Mehran University Research Journal of Engineering and Technology, 45(4), 84-91. https://doi.org/10.22581/0561

Similar Articles

11-19 of 19

You may also start an advanced similarity search for this article.